CORROSEAL INC -- RUST CONVERTER & PRIMER  -- 8010-00N045677
<pre>=====================  Product Identification  =====================

Product ID:RUST CONVERTER & PRIMER
MSDS Date:01/01/1993
FSC:8010
NIIN:00N045677
=== Responsible Party ===
Company Name:CORROSEAL INC
Address:1045 12TH AVE NW-F5A
City:ISSAQUA
State:WA
ZIP:98027
Country:US
Info Phone Num:206-392-6216
Emergency Phone Num:800-237-1573
CAGE:CRRSL
=== Contractor Identification ===
Company Name:CORROSEAL INC
Address:1045 12TH AVE NW-F5A
Box:City:ISSAQUA
State:WA
ZIP:98027
Country:US
Phone:800-237-1573
CAGE:CRRSL

=============  Composition/Information on Ingredients  =============

Ingred Name:PHTHALIC ACID, BIS (2-ETHYLHEXYL)ESTER; (DI(2-ETHYLHEXYL
    PHTHALATE) (DIOCTYL PHTHLATE)
CAS:117-81-7
RTECS #:TI0350000
Fraction by Wt: <3%
OSHA PEL:N/K 
ACGIH TLV:N/K 
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS

Ingred Name:GALLIC ACID
CAS:149-91-7
RTECS #:LW7525000
Fraction by Wt: <2%
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:ETHANOL, 2-(2-ETHOXYETHOXY)-, ACETATE;
    (2(2ETHYLETHOXY)ACETATE.
CAS:112-15-2
RTECS #:KK8925000
Fraction by Wt: <3%
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:VOLATILE ORGANIC COMPOUNDS
RTECS #:9999999VO
Fraction by Wt: 60% G/L
OSHA PEL:N/K 
ACGIH TLV:N/K 

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:NO
Reports of Carcinogenicity:NTP:YES    IARC:YES	  OSHA:NO
Health Hazards Acute and Chronic:SKIN:ACUTE:CONTACT MAY CAUSE IRRIT,
    PRLNG CONT MAY CAUSE BURNS. CHRONIC:EXPOS MAY CAUSE DERMAT.
    INGEST:MAY CAUSE HDCH OR NAUS & ABDOM PAIN. EYE:IRRIT, REDNESS.
    CHRONIC EXPOSURE MAY CAUSE CONJUNCTIVITI S. LISTED AS POTNTL CARCIN
    FOR HAZ COMMUNICATION PURPOSES BY NTP & IARC BUT MAY POSE LITTLE
    RISK TO MAN. DOP IS (SUPDAT)
Explanation of Carcinogenicity:PHTHALIC ACID, BIS(2-ETHYL HEXYL) ESTER:
    IARC MONOGRAPHS, SUPP, VOL 7, PG 56, 1987:GRP 2B. NTP 6TH ANNUAL
    RPT (SUPDAT)
Effects of Overexposure:HLTH HAZ:NON-GENOTOXIC, & NON-MUTEGENIC. IN 40
    YEARS OF INUSTRIAL USE DEHP HAS SHOWN NO OBSERVABLE CHRONIC HUMAN
    HEALTH HAZAARD. EXPLN NOTE:CARCIN:ANTICIPATED.
Medical Cond Aggravated by Exposure:DERMATITIS.

=======================  First Aid Measures  =======================

First Aid:EYES:FLUSH WITH FRESH WATER FOR AT LEAST 30 MINUTES.
    SKIN:WASH WITH WATER.INGEST:CALL A PHYSICIAN. VOMITING MAY BE
    INDUCED IF THERE IS NO DANGER OF ASPIRATION. INHAL:REMOVE TO FRESH
    AIR. SUPPORT BREAT HING (GIVE 02/ARTIFICIAL RESPIRATION) .

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:>200F,>93C
Extinguishing Media:LATEX EMULSION-NOT FLAMMABLE-DRY LATEX USE WATER
    FOG
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
    EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE-NON FLAMMABLE

==================  Accidental Release Measures  ==================

Spill Release Procedures:SMALL SPILLS PICK UP WITH ABSORBENT MATERIAL &
    PLACE IN DRUM FOR DISPOSAL. LARGE SPILLS-DIVERT TO HOLDING AREA &
    LET DRY. PLACE DRIED MATERIAL IN DRUMS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:DO NOT FREEZE, STORE IN CLOSED
    CONTAINERS.
Other Precautions:CLEAN UP EQUIPMENT & SPILLS BEFORE PRODUCT DRIES,
    PREVENT CONTAMINATION OF GROUND WATERS.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
    EXPOSURE OF CONCERN . NOT REQUIRED FOR MOST CONDITIONS, HOWEVER,
    USE NIOSH/MSHA APPROVED MIST RESPIRATOR IN ENCLOSED AREAS.
Ventilation:NOT REQUIRED
Protective Gloves:USE RUBBER GLOVES.
Eye Protection:CHEMICAL SPLASH GOGGLES.
Other Protective Equipment:WEAR BODY COVERING CLOTHING
Work Hygienic Practices:WASH HANDS; REMOVE CONTAMINATED OR WETTED
    CLOTHING.
Supplemental Safety and Health
CARCIN COMMENTS:ON CARCIN, 1991:ANTICIPATED TO BE CARCINOGENIC. ORAL
    ANIMAL:LIVER, TESTES, ENDOCRINE.

==================  Physical/Chemical Properties  ==================

HCC:C3
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.02(H20=1)
Solubility in Water:100% DISPERSIBLE
Appearance and Odor:THIN, MILKY WHITE/BEIGE LIQUID WITH MILD ODOR

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
ALKALIS, AMMONIA, IRON COMPOUNDS, OXIDIZING AGENTS.
Stability Condition to Avoid:FREEZING
Hazardous Decomposition Products:CARBON MONXIDE, ORGANIC ACIDS &
    ALDEHYDES.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
    AND FEDERAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.